sunglass holder clip broke,trunk lid not alligned, door chrome moulding loose, all 4 tire sidewall crack (dry rot). A clip on the replacement light was broken resulting in a reorder of the part.
The dealer tried refastening a panel underneath the car. This was a continuation of the seat squeak problem noted previously. Should the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering. VerticalScope Inc., 111 Peter Street, Suite 600, Toronto, Ontario, M5V 2H1, Canada. California consumers may exercise their CCPA rights here. Ive attached some pictures of it. To see how
Dec 26, 2006 [quote author=Showtime link=topic=65422.msg1121303#msg1121303 date=1167186958] Way to go Ford. Did not replace the motor as the cost for this was not acceptable from the dealers. Went to install part, but discovered it wasn't painted! Engine; Transmission and Drivetrain; Brakes and Traction Control; Suspension and Steering; Car had become a piece of rusty junk with a failed transfer box. This is not normal in todays vehicles. b.
Ford Cookie Notice I took my wife's car into the Ford dealership to replace the tie rods and do an alignment. Cheap ass plastic. We have meticously kept this vehicle clean and spray waxed. 42000 mi Front rotors warped. 2) surface preparation and inspection Needless to say, this is a very costly repair that I feel is Ford motor CO.s responsibility. Finish on passenger front door panel (closest to sideview mirror) came off after washing inside of window. by Susan B Sun Mar 27, 2011 1:29 pm, Post First time we had bubbling rust below the rear bright strip and was repaired under warranty (at 34,000 miles). Front vehicle photos 1986-2018 Autodata, Inc. dba Chrome Data. replace moonroof motor to open and close. The noise was most prominent at idle and low speeds but generally abated at speeds>40 mph. (6 Common Causes), https://www.consumerreports.org/cars/ford/fusion/, https://www.carcomplaints.com/Ford/Fusion/, https://www.carproblemzoo.com/ford/fusion/, https://caredge.com/ford/fusion/depreciation, https://www.lieffcabraser.com/defect/ford-coolant/, https://www.motor1.com/news/592353/ford-recall-nearly-3-million-vehicles-for-shifter-bushing-fault/, https://www.cargurus.com/Cars/l-Used-Ford-Fusion-d845, Ford Fusion Model Years With the Most Problems, Ford Fusion Reliability Compared to Similar Cars. Come join the discussion about performance, modifications, classifieds, troubleshooting, maintenance for the Focus, Fiesta, Taurus, Mustang and more! For example, newer cars will have fewer complaints simply because theyve been around for less time. It started when the temps dropped. This seal helps pressurize the gasses inside the combustion chamber and also keeps the oil and coolant from mixing together. Replaced weather stripping that was improperly installed from factory causing it to crack. Dealer cleaned tracks and lubed. Windshield was replaced due to few waves/defects in windshield, ordered and replaced at the dealer by outside glass shop. Dealer added padding to prevent noise. Driver's seat torn, ordered new seat cover. They said I needed a new subframe. We use cookies to analyze & improve your experience, & to personalize content and ads. Ford Fusion / Mercury Milan / Lincoln Zephyr & MKZ. Reddit and its partners use cookies and similar technologies to provide you with a better experience. buzzing noise coming from behind the steering column. Door rattle. Am very, very disappointed since I love the car and want to keep it for several more years. What kind of restrictions should I put on driving it (example, keeping the speed to <30mph etc)? 4) equipment and maintenance I took the car in to get safetied and both rocker panels are rusted out. Link must be about this specific problem or it will be deleted it must be free & helpful, like a video or web page or forum thread about this exact problem. Way to go Ford.
Gasket came off of sunroof glass due to rust in the gasket spine. Heard arcing sound, smelled burning smell, pulled fuse. Rear passenger cushion behind driver unable to support weight of occupant, deformation occurs that does not immediately dissipate when occupant exits seat. Part replaced, very expensive. A second recall covers 49,000 Ford Fusion, Lincoln MKZ, Ford Escape and C-MAX vehicles from 2013 and 2014. Identify issue and order part. Online estimates put the cost of a new throttle body, including parts and labor in the region of $1000. These engine troubles are believed to be caused by throttle body issues. Sunroof wind noise. I literally have a steady drip action in the ran and every thrip into a car wash. door release broke with normal use.
rattle when going over pothole. Dealership wanted to paint the old doors..(the 2 front). a. Mine is a 2006 Black SEL. NO FORUM HOMEPAGES. Started to notice wind noise inside vehicle. Writing for Cheatsheat.com, Micah Wright says in his May 3rd article: On April 29,Ford issued another recall, covering four different models in the Ford/Lincoln lineup, and one that directly effects more than747,000 vehicles. Dealer said couldnt help since out of warranty. Ford used the steel lug nuts from roughly the 2000 through 2015 model years, on car and truck models including the Focus, Fusion, Escape, F-150, Flex, C-Max, Expedition and F-350. Had to have it towed. The breakdown of the bushing has been linked to heat and humidity. Do not plan to have dealer do next repair. This recall mostly affected those from regions where the roads are heavily salted in the winter. Car handles like it is on rails. In the meantime, theres plenty of interior accessory problems to complain about. One thing every can seem to agree on is this: Bolts can rust, and rusty bolts can lead to dangerous driving situations. Replaced trim piece in steering wheel that controlled volume, radio selection, etc. Example: "Bad Brakes", "Toyota Recall", etc. bumper adhesive let go on top of rear bumper 2 days after i bought the car. Ford is issuing a safety recall for approximately 520,000 2013-15 Ford Fusion and Lincoln MKZ vehicles and certain 2015 Ford Edge vehicles in corrosion WebThe 2006 Ford Fusion has 1 problems reported for rust. Ask your Ford dealer.
Ford Recalling Over 400,000 Cars for Rusty Frames, Faulty If your Ford Fusion is stalling and hesitating it could well be caused by a faulty throttle body, in which case it will need to be replaced. A forum community dedicated to Ford Fusion and all Ford vehicle owners and enthusiasts. The power steering cut out while we were driving. Bought car with center vent broken / recessed into dashboard. The engine is going to have to be replaced. Dealer tried spraying formula on spots with no results. Some owners have been able to get away with just replacing the head gasket whilst other owners have had to replace the engine entirely. That may fix it. Very simple D.I.Y. are trademarks of Autobeef LLC, All rights reserved. Could not repair. It's a pain in the ass to try and have Ford fix it, but they wont unless its really bad. That hasnt been the case for a few 2021 Ford F-150 owners, however, as many of them are already facing various rust and corrosion issues mere months after taking delivery of their shiny new trucks. Dealer replaced entire dash. WebProblem Description The lug nuts on the Ford Fusion are known to swell to greater than their original size. Told Ford would not cover it even though under the 3/36 bumper-2-bumper warranty. 5 min job. I even wash and wax my door jambs where the rust formed! Brought back to the dealer several times in order to prove that a hard shift from 1st to 2nd and 2nd to 3rd gear was truly an issue. "CarComplaints.com" , "Autobeef", "What's Wrong With YOUR Car?" Fixed by owner. Inside driver door handle broke, dealer replaced during initial visit to deal with problem. Had it replaced. Privacy Policy. New appointment in January to replace pillar cover. Interior door latch handle on drivers door broke/deformed, Tires leaked - dealer unmounted tires and cleaned up corrosion on wheel/tire bead interface. Dealers will replace seat back frames that weren't welded properly. Got a part and fixed less than one hour. I had rust under the hood lip, trunk lip and drivers side rear door.
Rust or Corrosion | FordFusionClub.com Covered in next video Part 2; Application, Now sold throughout North America, our laboratory-engineered undercoating beats every product weve tested penetrating deep into seams and cavities to prevent rust and preserve your vehicle. IE 11 is not supported. Wrench light would come on and car would jerk and chug, lose acceleration (went into limp mode). Moonroof became unseated. register to join our community All rights reserved. Rust after Dealer repair, just before cutting. According to a recent report from Consumer Reports, Ford are ranked the 18th most reliable car manufacturer out of 28 brands, with a score of 44/100. All rights reserved. For the second time, the trunk decklid was exhibiting bubbling paint and rust forming. frequently Ford Fusion problems occur, check out our car reliability stats. I was in a rental for 1 day short of 1 month while this problem was handled. Drove through a puddle, underbody plastic "shield" pulled away. Passenger seatbelt squeeking. They were replaced. Black plastic exterior trim on drivers door behind mirror came loose.Repair was attempted, but failed again. That's not my fault, that's Ford's. Scan this QR code to download the app now. Replaced chrome grille. Dealer replaced.
Front vehicle photos 1986-2018 Autodata, Inc. dba Chrome Data. Average failure mileage is 20,950 miles. Most of the rattles are fixed although once in a while I hear them. The sunroof started opening and closing uncontrollably while driving. interior driver and passenger door handles broke. drivers door inner handle snapped causing the door not to lock and unable to exit the vehicle with the window closed, Had to replace the driver door handle as it broke and would not lock leaving the doors unable to lock. The SUVs were originally sold or registered in 20 states and Washington, D.C., where salt is used to clear snow and ice from roads. I have a 2008 SEL V6 w/the SAP package. Whether youre the owner of Fusion or in the market for a used one always run the VIN on using either Fords lookup tool on their website or on the NHTSA website to see if the vehicle has been subject to a recall. Our car has the Luxury Package but the car was built with the base model shift knob. Passenger side carpeting had small 2 inch rip in top right hand corner. Door wind noise. I'm shocked and it's really taken away my once renewed feeling about a "Ford product." For this article, we'll focus on the transmission issues, which can be a major concern. Advised by service adviser that although issue noted, unsure if can be fixed. Center console not fitting properly - caused by service to the car by another dealer - this dealer did not replace the trim properly. Make a Ford dealership do the body/paint work so it stays under warranty. Also in 2011, Ford recalled about 1.2 million pickups in snow areas to replace straps holding fuel tanks in place, which could corrode. Here is the first part of our 2017 workshop series. Plastic panels were "fixed" with double-sided foam tape. Dashboard had air bubbles in it. Now own a 2008 Audi A4 S-Line Quattro. This is on my hoodpreviously had the same problem on my doors which Ford covered but it was under warranty at the time.
Ford Fusion Rust I doubt that it would be covered by any warranty but just ask the dealer and see what they have to say about it. Ford issued a recall for the 2006 2010 Ford Fusion models due to problems with the valves within the ABS Hydraulic Control Unit, essentially the valves were prone to not closing properly negatively impacting the braking of the car. I took it into the dealer and they took pictures to send Replaced driver door lock mechanism and lever which were broken. The new roof also doesnt sit properly in the opening and the front driver side of it is noticeably lower than the rest and result in a little pond forming every time it rains. Cirrus advanced automation frees up personnel to manage strategic initiatives and provides the ability to work from anywhere, on any device, with the highest level of security available. replaced moonroof motor, rail, and one bolt & washer. If the power steering has failed because the engine has cut out you may need additional pressure on the brakes to stop the car. Front vehicle photos 1986-2018 Autodata, Inc. dba Chrome Data. Dealer says motor was burnt out. I've got rust forming in my door panels already! Driver's inside door handle broke. paint bubbling up on passenger side hood, leading edge due to corrosion under the paint, Paint bubbling on hood at site of previous dealer repair, sunroof was rattling, headliner was adjusted, Trim around rear speaker came loose.
Ford Fusion So, open the door and look below the child lock and from there, down to the bottom of the door, it's bubbling. Its news we hate to hear, especially on the coattails of a series of recent rollouts, but for the sake of safety, it must be done. I cannot open the door from the inside; I roll down the window and open it from the outside. Ford offers no spare part -- the entire glass must be replaced. I've got Replaced no charge under extended warranty. All site content Copyright 2006-var year=new Date(); year=year.getYear(); if (year<1900) year+=1900; document.write(year); FordFusion.net We are in no way affiliated with Ford Motor Company. Dealer cost $200. Knowing the right way to prevent and fix rust damage is an important part of living in Orange County.
2011 Ford Fusion Reliability - Consumer Reports Replaced grab handle above front passenger door. In its official statement, Ford says that customers located in non-corrosion states or provinces will be covered by extended warranty if they experience similar concerns.. This widespread Ford Fusion and Lincoln recall is directly related to corroded bolts that thread into the steering-gear motor. WebIt appears to be part of the subframe that the sway bar attaches to. Plastic trim was rubbing on metal frame, was repaired by padding metal frame. How Long Do Ford Fusion Hybrids Last? The media.Ford.com page it refers to, however, seems to indicate the recall affects only a little over 500,000 vehicles and three models. Started squeaking again within 24 hours. Re-wrapped wiring harness. 2011 Ford Fusion problems. "popped out". Still pending parts. Replace back and from left seat leather for unusual cracking. Airbag related problems have been widely reported on 2006, 2007, 2008, 2009, 2010, 2011 and 2012 Ford Fusion Models. Fuel filler door not aligned correctly. Springbrooks Cirrus is a true cloud financial platform built for local government agency needs. This is a known problem in the 2013 to 2019 Ford Fusions. Inside of sunroof was rusted, no evident leaks. Headliner separated and began sagging in the rear of the car. This is the number one complaint on the site for the 2017 model year. Drive side interior door handle broke. We use cookies to analyze & improve your experience, & to personalize content and ads. Door handle stays in the open. Inside driver side door handle broke (was not abused). Also included are the Canadian corrosion provinces of Ontario, Quebec, Prince Edward Island, Newfoundland and Labrador, Nova Scotia and New Brunswick. Members can start their own topics & subscribe to topics Rubber seal on back window was loose - repaired successfully by dealer. An extended warranty can provide peace of mind. If the steering gear motor bolts fracture, the steering system may default to manual steering mode, making the vehicle more difficult to steer, especially at lower speeds. A kit was installed by the dealer. Ford says the subframes can rust, allowing a control arm to separate and hamper steering control. Trunk lid repainted. Was told parts from problem had arrived. Owners also report the issue caused their vehicle to completely stop working. My car is washed religiously a couple times a week and weekly in winter.
Social Impact Certificate Programs,
Bernard And Goodyear, 2004,
Jamaican Chicken Patties Recipe,
Articles F